|
_____ Clean Air filters
_____ Brakes bled & Adjusted especially if overheated
_____ Bumpers & Chassis bolts
_____ Belts & harnesses Chaffing or pulled webbing
_____ Brake fluid
_____ Fuel lines
_____ Check fuel lines to cell B4 washing cover w/ rag then cover w/ a bag then another Rag & a bag.
_____ Magneto cap & rotor
_____ Drive line
_____ Front caliper & rotor
_____ Fuel filter
_____ Freeze plugs
_____ Fill Fuel Can, Quad & Generator
_____ Front Bars
_____ Front Hubs & wheel bearings
_____ Front shocks & mounts
_____ Front end alignment
_____ Fuel cell inspected
_____ Headers & header bolts
_____ DZUS Buttons
_____ Heim ends & brackets
_____ Ignition wiring & coil
_____ Clean & Grease Arms Axle where they set
_____ Master cylinder
_____ Motor mounts
_____ Change Oil & Filter
_____ Torq Tube
_____ Rear calipers & rotor
_____ Rear brake lines & brackets
_____ Rear Axle
_____ Radiator cleaned CAREFULLY
_____ Radiator mounts
_____ Radiator filled
_____ Radiator cap
_____ Change Gears & Fluid
_____ Rear-end level
_____ Rear-end housing
_____ Rear hubs Bearings
_____ Grease Rear Arms
_____ Rear shocks & mounting
_____ Check Chassis Cracks (good to do while hand washing)
_____ Check Wing
_____ Spark plug wires
_____ Spark plug gap & wear
_____ Spark plugs replaced ?
_____ Lube Shifter
_____ Spindles & steering arm
_____ Steering linkage & ends
_____ Throttle return springs
_____ Timing set
_____ ChangeTires
_____ Arm Clearance
_____ Valve cover bolts & gaskets
_____ Valve lash checked
_____ Wheel cylinder or caliper
_____ Water hoses & clamps
If flush fuel system run WD-40 through system, Do not use an anti-seize with a gritty texture it will cause excessive wear of your parts.
washing car put ballons over fuel tank vent. Remove panels when washing, power washing use care around rear axle bearings.
|